Refrigerated Air Dryer Installation

Understand the pressure limitations to your air dryer.

Refrigerated air dryer installation.

The condensed moisture carries airborne dirt and oil to the moisture separator. The use installation of a back pressure regulator will overcome this issue by only allowing air out the dryer area above a set pressure e g. Refrigerated air dryers are one of the most common air compressors add ons due to their relatively low cost and high efficiency. Then the incoming air enters an air to refrigerant heat exchanger where the air is cooled to 38º f by the liquid refrigerant.

Like wise during the start up period of an air system a refrigeration dryer can come under stress due to low inlet pressures while the system is in the start up phase. The lower compressed air temperature causes trapped water vapor to condense. Grainger s got your back. Install a refrigerated air dryer.

The refrigerated air dryer will chill the compressed air to about 39 f. Install a refrigerated air dryer. Connect an air hose or pipe from the compressor s discharge to a good quality coalescing or particulatefilter. Air dryers are not the only solution the air dryer suppresses the dew point which removes the bulk of the moisture in the.

Where the upstream piping isn t stainless steel install a mist eliminator as close as possible to the inlet of refrigerated dryers or a desiccant dryer s prefilter. Air compressor hp 3 hp 3ya49. A refrigerated compressed air dryer is a type of compressed air dryer used to dry compressed air. To protect your piping tools and equipment it s best to use a compressed air dryer to dry the air.

Looking for speedaire compressed air dryer 10 cfm max. Easy online ordering for the ones who get it done along with 24 7 customer service free technical support more. Our air dryers purify compressed air by chilling it to condense the moisture leading to cleaner air and a longer life for your valuable equipment. The refrigerated air dryer cools the incoming compressed air first in an air to air heat exchanger where the outgoing cool dry air pre cools the hot incoming air and condenses some moisture out.

Connect your air hose or pipe from the filter s discharge to the dryer s inlet. Compressed air always contains water coming from the air that is sucked in by the compressor.